Duct Mount Centrifugal Atomizer Humidifier PDF Manual Installation
Your centrifugal atomizer type humidifier operates on the principle of breaking down water droplets into a fine mist and atomizing the moisture into the air. If applicable, set the humidistat in the recommended range of 30-40% relative humidity for automatic humidity control during the heating season (a lower setting may be used to control condensation on single pane windows). During the first heating season, check the mineral
buildup in the humidifier every month to establish the proper cleaning schedule. Clean the unit at the end of each heating season, or whenever mineral deposits appear to be impeding the discharge of the water mist.
When shutting the humidifier down for the summer months, start with cleaning any mineral accumulation from the unit. Leave the water turned off and the unit dry. If the furnace fan is to be used for cooling purposes, disconnect power to the humidifier or turn the humidistat to
the OFF position.
Mounting on face of vertical return duct or side of horizontal return duct
When mounting your humidifier on the face of a horizontal return duct, or on the face of a vertical return duct, certain conditions must be met for its proper operation:
• Mount the humidifier on the vertical or horizontal cold air return duct.
• Locate the humidifier at least four (4) linear feet upstream of either the furnace fan and /or filter and any turn in the duct. This will ensure that condensation does not collect within the duct and cause oxidation (rust). • Mount the humidifier at least six (6) linear feet (preferably 10 feet) upstream from any electronic air cleaner. Failure to follow this ecommendation can cause excessive nuisance arcing and or power supply failure.
• If the duct seams inside the duct are not flat, locate the humidifier at least three (3) linear feet upstream from the seam.
• If the humidification needs of the home require more than one humidifier, each unit should be installed a minimum of (3) linear feet apart. • DO NOT use this humidifier on the discharge or warm air supply side of a forced air heating system. This will reduce the efficiency of the humidifier and may cause operational problems.
Download Duct Mount Centrifugal Atomizer Humidifier PDF Manual Installation
Related E-Books:
- None Found
December 5, 2009 | Posted in Electronic Manual, Humidifier Manual
Comments
Leave a Reply